Thermodynamic study of Liquid-Liquid Equilibria in Ternary System of Methanol, Toluene, and Hexane

Fatima Ahmed Aldahish

doi:10.65405/a2kqq743

المؤلفون

Fatima Ahmed Aldahish Department of Chemical Technology, Surman College of Science and Technology- Libya المؤلف

DOI:

https://doi.org/10.65405/a2kqq743

الكلمات المفتاحية:

Liquid-liquid equilibrium; Methanol; Toluene; Hexane; Thermodynamic modeling; UNIQUAC; NRTL

الملخص

Liquid- liquid equilibrium (LLE) data are essential for the design and optimization of liquid- liquid extraction processes in chemical and petrochemical industries. In this work, experimental LLE data for the ternary system {Methanol + toluene + hexane} were investigated at 298, 303 ,308 and 313K under atmospheric pressure 101.3 KPa, The equilibrium composition of the coexisting liquid phases were determined and used to construct bimodal curves and tie-line data for the system. Distribution coefficient and separation factors were calculated in order to evaluate the extraction performance of toluene for separating methanol from hexane. The reliability of the experimental tie-line data was examined using Othmer-Tobias and Hand correlations. The experimental data were correlated using the NRTL and UNIQUAC thermodynamic models. Both models successfully represented the phase equilibrium behavior of the system, with the UNIQUAC model showing slightly better agreement with the experimental results. The average root mean square deviation (RMSD) values were approximately 1.013% for UNIQUAC and 1.189%for NRTL.

التنزيلات

تنزيل البيانات ليس متاحًا بعد.

المراجع

1- Nagata, I.: Liquid–liquid of (methanol + cyclohexane +chlorobenzene) and of (methanol + methylcycohexane) +benzene, + ethanol, and + toluene at 298.15 K. J. Chem. Thermodyn. 16, 737–741 (1984)

2- M.Mohsen-Nia, F. S. Mohammad Doulabi. Liquid–liquid equilibria for mixtures of (ethylene carbonate + aromatic hydrocarbon + cyclohexane ) . Thermochimica Acta Vol 445 , 82-85, (2006) .

3- Jonatan Hernan Veliz, Alicia Marta Cases,Constanza Geraldine Varas Gutierrez&Monica Beatriz Gramajo . Influence of Temprature on Liquid-Liquid Equilibrium of Methanol + Toluene + Hexane Ternary Systems at Atmospheric Pressure , Vol47 Jsolution Chem 47:1529-1538(2018).

4- Fariborrz Shaahma di, Mohammad Amin Anbaz, Bahamin Bazooyar. The Analysis of liquid- liquid equilibria (LLE) of toluene+ heptane+ ionic liquid ternary mixture using intelligent models. Chemical Engineering Research and Design, pases 184-198, February 2018.

5- Emilio J. Gonzalez, Noelia Calvar , Begona Gonzalez, and Angeles Dominguez. Liquid-Liquid Equilibrium for ternary mixtures of Hexane+ Aromatic compounds + [EMpy][ESO4]at 298.15K, J.chem.Eng.data ,55,2,[633-638],2010.

6- Amir Hosseini, Reza Hagh bakhsh, Sona Raeissi. Experimental Investigation of liuid- liquid Extraction of Toluene+ Heptane+ or Toluene+ Hexane using Deep Eutectic solvents. Journal of chemical&Engineering Datat,64(9),3811-3820, 2019.

7- Renon, H., Prausnitz, J.M.: Local compositions in thermodynamic excess functions for liquid mix‑ tures. AIChE J. 14, 135–144 (1968) .

8- Abrams, D.S., Prausnitz, J.M.: Statistical thermodynamics of liquid mixtures: a new expression for the excess Gibbs energy of partly or completely miscible systems. AIChE J. 21, 116–128 (1975).

9- Xuemei Zhang , Feiyan Yang , Chungui Jian, Hongweiwang , Wangxin Kong , Guangjin Shangguan , Meifang Xia, Liquid liquid equilibrium for the ternary system of (2-methyl-2-butanol+water+n-octanol) at different temperatures , J.Chem . Thermodynamics 161106522,(2021).

10- The properties of gases &liquids 4th edition Robert c. REID Jom . M PRausnitz Bluce E.Poling.

11- Wenyang fan , Qing Li, Dongmei Xu, Jun Gao, Huiwen Huang , and Yinglong Wang . measurement and thermodynamic modeling of Liquid -Liquid Equilibrium Data for ternary system (Water + Formaldehyde + Methyl Isobutyl Ketone/ Cyclohexanone) at Different Temperatures, 8-June2022.

12- Soumaya Larous ; Nadjet Boulkroune ; Aicha Nekaa , Rania Tautaou , (Departement du Genie Pharmaceutique . Liquid- liquid Extraction of Methanol from aqueous solutions using n-Hexane and Toluene as solvents, Laboratoire de L"Ingenierie des Procedes d'Environnement , Faculte du Genie des procedes, University Salah Boubnider Constantine 3, 25000, Algerie )17-7-2022.

13- Jonatan Hernan Veliz, Alicia Marta Cases,Constanza Geraldine Varas Gutierrez&Monica Beatriz Gramajo . Influence of Temprature on Liquid-Liquid Equilibrium of Methanol + Toluene + Hexane Ternary Systems at Atmospheric Pressure , Vol47 Jsolution Chem , 47:1529-1538, (2018) .

14- Mo ´nica B. Gramajo • Jonatan H. Veliz • Marı ´a C. Lucena • Diego A. Gonza ´lez. Liquid–Liquid Equilibria of the Methanol + Toluene + Methylcyclohexane Ternary System at 278.15, 283.15, 288.15, 293.15, 298.15 and 303.15 K , , Springer Science+Business Media New York 2013.

15- Letcher and Redhi liquid liquid equilibrium for ternary system of

liquid mixtures of ) benzonitrile + acetic acid or propanoic acid or butanoic acid or 2-methylpropanoic acid or pentanoic acid or 3-methylbutanoic acid + water) at T = 298.15 K. J. Chem. Thermodynamics Vol 344 , 700-811, (2011) .

16- Rappel et al liquid liquid equilibrium for ternary system systems: (sulfolane + p-xylene + n-hexane) and (sulfolane + toluene +nhexane) at 308.15 K and 323.15 K. J. Chem. Thermodynamics Vol 48 , 1006-133, (2007) .

17- Al-Dujaili et al liquid liquid equilibrium for ternary system systems

[sulfolane + 1-alkanol (C1 to C5) + octane + toluene] at 293.15 K. J. Chem. Thermodynamics Vol 38 ,1036-1041, (2006) .

18- Schmitt and Hasse Liquid-liquid equilibria of water + 1-hexanol, water+ hexyl acetate, water + acetic acid + 1-hexanol, and water + acetic acid + hexyl acetate at temperatures between (280 and 355) J. Fluid Phase Equilibria. Vol 27, 199-204, (2006) .

19- Kao and Lin liquid liquid equilibrium for ternary system of (alkanes, C10 / C12 / C14 + 1.4-diisopropylbenzene + sulfolane) at T = 323.15 K, 348.15 K and373.15 K .J. Chem. Thermodynamics Vol 239 ,156-160, (2006) .

20- Yu et al (Liquid + liquid) equilibria of the (sulfolane + aromatic hydrocarbon) at infinite dilution rnary system. J. Chem. Thermodynamics Vol 38 , 696-700, (2006).

21- Yao Chen , Caiyu Wen. liquid liquid equilibrium for ternary system at 298.15 K under atmospheric pressure for (water + propanol + diethyl carbonate (DEC) + benzene or cyclohexane or heptane) quaternary systems and (water + DEC + propanol- or benzene or cyclohexane) J. Chem. Thermodynamics Vol 37 ,1144-1150, (2005) .

22- Liejin Luo , Dong Liu , Libo Li , (LLE) data for the ternary system 2-methoxy-2-methylpropane (methyl tert-butyl ether) + o-cresol + water were experimentally measured at atmospheric pressure and temperatures of 298.15 K and 313.15 K. J. Chem. Engg. Vol 59, 3631-3647, (2004) .

23- Liu et al. (Liquid + liquid) equilibria in some free fatty acids Free Fatty Acid (FFA) with methanol .J. Chem. Thermodynamics Vol 35 ,1393-1401, (2003) .

24-Naydenov and Bart Liquid-liquid equilibria for alcohol (1-propanol or 1-butanol) or acetic acid + ester + the ionic liquid 1-ethyl-3-methylimidazolium hydrogen sulphate [EMIM] [HSO4] were studied at (313.2 ± 0.5) K Fluid Phase Equilibria. Vol 200 , 287-293, (2002) .

25- Erol İnce, Melisa Lalikoglu , Liquid–liquid equilibrium (LLE) data of water + acetic acid + 2-ethyl hexyl acetate at 298.2, 308.2 and 318.2 K

Fluid Phase Equilibria. Vol 187-188 , 265-274, (2001).

26- Urszula Domańska liquid–liquid equilibrium data for the ternary system for alkyl-piperidinium-based and phosphonium-based ionic liquids (ILs). T = 308.15 K and p = 101.33 kPa J. Fluid Phase Equilibria. Vol 190 ,179-189, (2001).

27- Kinart et al liquid–liquid equilibrium data for the ternary system for sulfolane + 2-methoxyethanol or 2-ethoxyethanol, 2-propoxyethanol J. Fluid Phase Equilibria. Vol 163 , 243-257, (1999).

28- Khayati, Gholam (LLE) data for the ternary system methylcyclohexane + methanol + ethylbenzene. at 288.2 K. J. Fluid Phase Equilibria. Vol 157 (1999) .

29- Hui Wang , Qinbo Wang (LLE) data for the ternary system water + benzyl alcohol + methylbenzene were measured at (303.2 to 343.2) K under atmospheric pressure , Fluid Phase Equilibria. Vol 137 ,163-172, (1997).

30- Jingjing Chen , Tingping Xie Liquid–liquid equilibrium (LLE) data water + acetone + dihydromyrcenol were measured at 358 K to 368 K

C. J. Fluid Phase Equilibria. Vol 108 , 269-292, (1995).

31- Kinart et al liquid liquid equilibrium for ternary system system

sulfolane with ethylene glycol, diethylene glycol, triethylene glycol and tetraethylene glycol systems at 303.15 K. J. Chem. Engg. Data. Vol 33 ,258-260, (1988) .

32- Mohsen-Nia and Paikar LLE of ternary and quaternary systems containing n-hexane, toluene, m-xylene, propanol, sulfolane and water at T = 303.15 K J. Chem. Engg Data. Vol 33 ,16-20, (1988).

33- Erol İncea , liquid–liquid equilibrium data for the ternary system water + ethanol + mixture of dibasic esters (dimethyl adipate + dimethyl Chem. Engg. Data. Vol 11 ,353-356, (1966).

34- Romain Richarda, Nicolas Ferrando b, Marc Jacquin Liquid–liquid equilibrium data for acetic acid + n-butyl acetate + hydrocarbons ternary systems at T = 293.15K ,// hal .archives- ouvertes .fr /hal -01065438, 1985.

35- Kirbaslar S. Ismail liquid-liquid equilibria of the water- acetic acid - butyl acetate system at temperatures of 298.15 ,303.15 and 308.15 K

J. Fluid Phase Equilibria. Vol 149 139-145, (1998) .

36- Abrams, D. S.; Prausnitz, J. M. Statistical Thermodynamics of liquid Mixtures: A New Expression for the Excess Gibbs energy of Partly or Completely Miscible systems. AIChE Journal, 116-128, 1975 .

37- Vera, J.H.; Sayegh, S.G.; Ratcliff, G.A. A Quasi Lattice-Local Composition Model for the Excess Gibbs free energy of Liquid Mixtures. Fluid Phase Equilibria,113-135, 1977.

38- S.Ismali Kirbaslar. •(Liquid + liquid) equilibria of the (water + butyric acid + dodecanol) ternary system. J. Chem. Thermodynamics Vol 38 (2006)

39- . Mostafa Vatani, Gholamreza Vakili- Nezhaad, Morteza Asghari. Calculation of the UNIFAC and ASOG Group Interaction Parameters Using Genetic Algorithm in Ternary Extraction Systems Containing Ionic Liquids , Canadian Journal on Chemical Engineering & Technology Vol. 3 No. 2, March 2012.

40- H. Renon and J. M. Prausnitz, Local Compositions in Thermodynamic Excess Function for Liquid Mixtures, AIChE J. 14, 135-144(1968).

41- D. S. Abrams and J. M. Prausnitz, Statistical thermodynamics of liquid mixture: a new expression for the excess Gibbs energy of partly or completely miscible systems, AIChE J. 21 116-128,(1975).

42- G. Maurer and J. M. Prausnitz, on the derivation and extension of the UNIQUAC equation, Fluid Phase Equilib. 2 91-99, (1979).